What point does the need of room of spray paint of choose and buy take seriously?

Update time: 2020-10-14 19:59:09 authors: Origin of grand rich environmental protection: Http://www.zjhobo.com/vipjz11/vip_doc/18641710.html

　　Spray paint room is the room that object of spray paint of an opposite filter has spray paint. Spray paint room is to offer besmear to mount operation the equipment of special environment, exercise of outfit of can contented besmear is clean to temperature, humidity, illuminance, air degree wait for a requirement, the Qi Wu of the generation when it can work spray paint and organic waste gas are restricted and processing hind is discharged, it is environmental protection model besmear furnish equipment.

What the basis handles way to Qi Wu is different, room equipment can divide spray paint to be mixed for dry type wet two kinds. Room of dry type spray paint but an organic whole of spray paint, drying saves investment. Wet efficiency of mist of lacquer of processing of spray paint room is tall, can divide again for water (oily) shade type, bath type, water type coming back. Spray paint room is average catch market system by the room body, system sending wind, system that discharge wind, water supply, Qi Wu (Qi Ni processing system) , condole of the system that offer lacquer, workpiece hangs system, electric equipment to control a system (lighting system) wait for composition.

The design parameter of room of general spray paint asks as follows:

1, illume: Bright brightness needs to achieve inside spray paint room 800, 1000 lux, and need uses the light that approachs D65 illuminant, at the same time the wall inside the room should be dumb smooth white. The area that should use stationary to lamps and lanterns makes light source and use lamps and lanterns of clapboard general furnish when using the clapboard illume that waits for transparent material through glass and electrostatic paint division are separated, its install aperture to should take reliable sealed step, the material of clapboard is flame retardant with not easy damaged and the intensity of illumination that the deposit ply on clapboard must not affect a provision.

2, air flow: Usually to doing room of type spray paint, fan pressure head is desirable 0.7-1.0KPa, to wet spray paint room, fan pressure head is desirable 1.26-1.5KPa, the belt of working area carries wind speed to take 0.3-0.5m/s commonly.

3, filter the effect: Filter remove dust the effect achieves 98% above. The top cotton that repairs a factory to use commonly has EU5 and EU6 two model, sunlamp illuminate upside can be used inside the room when room of use spray paint, normally extremely tiny speck should be less than every square metre 5.

4, room body: Spray paint room must be sealed, and be in in juncture not due Qi Chen’s accumulation; House system is used child the mother inserts wallboard of model of gush of type heat preservation, it is sealed, good to defend lukewarm performance of spray paint room, aluminium alloy wraps side entrance door, contain in the center of the door viewport, can observe the trends inside the room at any time; House system flank contains working door, pass in and out of convenient staff member.

5, warm up speed: The time that spray paint room rises to be used to 60 ℃ place from 20 ℃ is L0 about, L5min, the thermometer that should notice room of some spray paint at the same time forbids, when measuring temperature, want with the spray inside spray paint room temperature is accurate.

6, noise: Noise is not more than 75dB.

The place on put together is narrated, the design point of spray paint room is:

1, affirmatory and reasonable configuration form.

2, air of affirmatory and reasonable spray booth horizontal is average velocity of flow.

3, send wind, platoon wind the system reasonable match, make sure spray paint is indoor small pressing.

4, illume distribution is equitable.

5, of Qi Wu purify a method reasonable, cannot discharge the gas with serious pollution to atmosphere.

Should consider to eliminate when the design in addition electrostatic; Chosen lamps and lanterns, switch must explosion proof, lest be when open,produce risk. Return the relevant law laws and regulations that must accord with our country.